2021 BMW 5 Series Battery Replacement (Car)
Complete guide to 2021 BMW 5 Series battery replacement (car). Cost estimates, difficulty level, time required, and environmental impact.
🌍 Share Your Environmental Impact
Inspire others to repair instead of replace! Share how much CO₂ you're saving.
💰 Cost Breakdown
💡 Tip: Costs vary by location and repair shop. Authorized service centers typically charge more than independent repair shops.
🔧 Repair Overview
Battery Replacement (Car) is one of the most common repairs for 2021 BMW 5 Series. This repair involves replacing the damaged electrical component with a new or refurbished part. The process typically takes 30 min and requires easy skill level.
What You'll Need
- Replacement electrical part (OEM or aftermarket)
- Precision screwdriver set (Phillips #000 or pentalobe)
- Opening tools (plastic spudger, suction cup)
- Adhesive strips or glue
- Clean workspace with good lighting
Step-by-Step Process
Step 1:
Try and see first if the key was simply "forgotten" by the car by reprogramming it:
Open the car with the second key, get in and close the door, but don't shut it all the way.
Put the key that needs to be reprogrammed into the starter and turn it to the "Radio" position. Leave it in this position for a few seconds and then pull it back out. The system is now ready for reprograming.
Press and hold-down the "open" button and then press the "close" button three times. Now, let go of the "open" button. The locking system should respond by locking and unlocking all doors, with a "click-clack"
***Important***: The second key must be reprogrammed within 10 seconds, otherwise it will no longer work. For this it must not be put back into the starter.
If this worked, you can stop - otherwise, follow the next steps.
Step 2:
The two halves of the casing are glued together. Separate the seam between the upper and lower casing with a sharp utility knife.
The process is tricky and time-consuming, cutting again and again around the key. Work slowly and patiently.
Don't cut deeper than 3 millimeters, so you don't come into contact with the circuit board.
Step 3:
When the seam is open wide enough, slide a pick inside.
Then separate the casings with an appropriate tool.
Step 4:
Here is what the inside of the casing looks like. The circuit board has already been removed.
Step 5:
The circuit board.
The battery type is VL2020. Pay attention to the welded flag connectors, which are in right angles of each other.
Step 6:
Desolder the battery from the solder pads marked in red.
Use a [product|IF145-473|desoldering pump] or desoldering wick.
Lift the battery out carefully.
Step 7:
If there isn't an insulation layer on the back, then place a piece of insulation tape there.
Step 8:
Put everything back together. Do not glue the casings yet. Instead, hold them together with a rubber band.
Check whether the micro switches are clicking. If not, move the circuit board back into the right position again.
Normally, the key - as mentioned in step 1 - will have to be reprogrammed. And don’t forget about the second key.
When everything is working, you can glue the two halves back together with the appropriate glue – for instance Super Glue – and carefully sand off any excess glue.
📖 Repair guide provided by iFixit - The free repair manual. Licensed under CC BY-NC-SA 3.0.
iFixit Difficulty: Moderate | Time: NaNh NaNm
DIY vs Professional Repair
✋ DIY Repair
- ✅ Lower cost (parts only: $60-$120)
- ✅ Learn new skills
- ❌ Risk of further damage
- ❌ No warranty
- ❌ Requires tools and time
🔧 Professional Repair
- ✅ Expert installation
- ✅ Warranty included
- ✅ Faster turnaround
- ❌ Higher cost ($100-$200)
- ❌ Need to find reputable shop
Environmental Impact
By choosing to repair your 2021 BMW 5 Series instead of replacing it, you're preventing approximately 6485 kg of CO₂ emissions. Manufacturing a new 2021 BMW 5 Series generates 6500 kg of CO₂, while this repair only produces about 15 kg of CO₂. That's a 100% reduction in carbon emissions!
Get a Personalized Repair Estimate
Upload a photo of your 2021 BMW 5 Series and get an AI-powered cost estimate in seconds. See exactly what's damaged and how much it'll cost to fix.